February 17, 2013, 8:21 pm
by Sam Rajappa
ACCORDING to the Department of Atomic Energy and the authorities of Nuclear Power Corporation of India, the loading of uranium fuel rods at the 1,000 MWe-capacity first unit of the Koodankulam Nuclear Power Project was completed on 2 October last year, but has not produced a single unit of electricity so far. Critical equipment supplied by Atomstroyexport of Russia, building nuclear reactors abroad, were found to be shoddy and have developed leaks even before commissioning of the plant. The financial statement released by Atomstroyexport shows its losses have doubled in the last year and it is on the brink of bankruptcy. Russian engineers at the Koodankulam plant site have not been able to plug the leaks. In a desperate attempt to commission the plant, as Prime Minister Manmohan Singh has made it a prestige issue, NPCIL has flown in technicians from Croatia and Germany to carry out repairs in the Russian designed and erected plant. NPCIL claims to have spent an excess of Rs. 4,500 crore on the non-functioning power plant. The People’s Movement Against Nuclear Energy has threatened to lay siege on the Koodankulam nuclear complex in a non-violent manner if the Centre commissions the first unit in haste and secrecy without attending to its safety requirements, and sought a White Paper on the KKNPP and its reactors from the Centre. It was turned down.
An official statement issued by NPCIL on 25 January said the Atomic Energy Regulatory Board has given permission to “repeat the full systems test at the first unit.” One needs to repeat a test only if it failed in the first instance. NPCIL’s desire to gloss over its failure and make it seem as if the ‘permission’ is a hard-won victory is understandable. But why is the AERB condescending even after RK Sinha, chairman of Atomic Energy Commission, had said that “there are some system parameters like flow, pressure, temperature that need to be maintained within particular values.” During the first hydro test conducted last December, certain valves did not behave the way the manufacturer claimed they would. These valves were opened, repaired, and some components replaced. The fact that brand new valves malfunctioned raises questions about the quality of equipment supplied. Identification of defective valves at this late pre-commissioning stage suggests that the quality of assurance of individual components was deficient.
In February last year, Russia’s Federal Security Service arrested Sergei Shutov, procurement director of Rosatom subsidiary Zio-Podolsk, on charges of corruption and fraud. Zio-Podolsk is the sole supplier of steam generators and some other key components for Russian nuclear reactors worldwide, including India. Shutov was charged with using cheap Ukranian steel blanks in nuclear reactors. NPCIL should reveal whether the leaky valves were supplied by Zio-Podolsk. A PTI feature issued in July 2011 reveals, quoting DAE sources, that the Koodankulam plant was expected to be commissioned in March 2009, long before protesters held up work on the project for nearly six months, but was delayed because of difficulties experienced in receiving equipment from Russia “in sequential order.” The article says: “The designers discovered that several kilometers of power and control cables in the reactor were missed after the completion of double containment of the reactor.” The problem was rectified after the cables meant for power supply to instrumentation in different buildings were incorporated by breaking open the concrete walls in the containment domes and was sealed again bringing the cables from the switch yard to inside. Breaking open and resealing the containment dome is unprecedented in nuclear power industry.
As the Manmohan Singh government is determined to unleash all kinds of atrocities on peaceful protesters against the shaky Koodankulam plant like filing 325 cases including sedition, waging war on the Indian State and on other serious sections of the Cr PC and IPC with 5,296 named as accused and 221,483 unnamed accused at one police station alone near the plant site, PMANE has taken up the issue with Congress vice-president Rahul Gandhi who had earlier reached out to the tribal people opposed to Vedanta Resource’s Rs. 4,500-crore bauxite mining project in Orissa’s Niyamgiri Hills. Rahul had then said: “True development takes place by respecting the interests of the poor,” and offered to be their sipahi in Delhi. SP Udayakumar, coordinator of PMANE, in a letter to Rahul, said if the Congress did not respect people’s power, democracy and peaceful struggles, and starts the Koodankulam plant forcibly, it would prompt the voters at least in Tamil Nadu and Kerala to shun the Congress.
Unmindful of the people’s fears about the breaking open and resealing of the dome of the Koodankulam plant, the AERB, DAE and NPCIL remain tight-lipped. Even a small mishap in a nuclear facility will have the potential to destroy millions of people in our densely populated country. In a recent report, the Comptroller and Auditor-General of India has passed strictures on the ‘toothless’ AERB for not even ensuring nuclear and radiation safety in any of the atomic installations in the country. The long-awaited Nuclear Safety Regulatory Authority Bill, tabled in the Lok Sabha on 7 September 2011, ostensibly to bring about much needed independence and transparency in administering safety of nuclear operations, remains a non-starter. According to A Gopalakrishnan, former chairman of AERB, the Bill fails to serve any of its laudable objectives in its present form.
The Bill seeks to establish a Council of Nuclear Safety to be chaired by the Prime Minister and will have as its members five or more Cabinet ministers, the Cabinet Secretary, chairman of the AEC and experts nominated by the Union government. The CAS will constitute two search committees, one to select the chairperson and the other to select members of the NSRA. The CNS is empowered to create an Appellate Authority to hear any appeals on any order or decision of the NSRA. The same Appellate Authority will also decide on appeals from the government against the NSRA. What the government tries to do under this Bill is to create a high level council under the chairmanship of the Prime Minister to control and curb the freedom of action of the NSRA. Clause 20 of the Bill stipulates the NSRA should function in a manner consistent with the international obligations of India.
If the NSRA were to find the equipment supplied by Russia to the Koodankulam plant substandard and do not conform to safety norms, the regulatory body dare not act for it would be contrary to “India’s international obligations” Prime Minister Manmohan Singh has promised unilaterally to his Russian counterpart while on a visit to Moscow in December 2011.
The same clause also says the NSRA “shall not interact with bodies outside India without the prior approval of the government.” The subservient nature of the proposed NSRA has been made abundantly clear in Clause 48(1) which says: “the Central government may, by notification, supersede the regulatory authority for such a period not exceeding six months. Upon notification, the chairperson and members of the NSRA shall vacate their offices as such; … all the powers, functions and duties shall, until the authority is reconstituted, be exercised and discharged by the Central government.” The NSRA can never be independent unless the appointment of its chairperson and selection of members of the regulatory authority as well as supersession of the NSRA are left to Parliament and not to the ruling party of the day. (The Statesman/ANN)
The writer is a veteran journalist and former Director of Statesman Print Journalism School
- Tell #India the Truth on the KKNPP (kractivist.wordpress.com)
- Jaitapur a critical issue: It’s all about money, honey! (kractivist.wordpress.com)
- Jaitapur nuclear power plant :A very expensive proposition (kractivist.wordpress.com)
- #India- Govt Bluffing the Country on Koodankulam Safety: M G Devasahayam (kractivist.wordpress.com)
- India importing nuclear reactors to please foreign countries; former AERB chairman #WTFnews (kractivist.wordpress.com)